A novel, green, cost-effective and fluidizable SiO2-decorated calcium-based adsorbent recovered from eggshell waste for the CO2 capture process

• Published in: Separation and purification technology 2023-01, Vol.305, p.122523, Article 122523
• Main Authors: Imani, Mehri, Tahmasebpoor, Maryam, Enrique Sánchez-Jiménez, Pedro, Manuel Valverde, Jose, Moreno, Virginia
• Format: Article
• Language: English
• Subjects: Calcium looping; CO2 capture; Eggshell; Fluidization; Hydration; Sol-gel
• ISSN: 1383-5866; 1873-3794
• DOI: 10.1016/j.seppur.2022.122523

[Display omitted] •Novel SiO2-decorated Ca-based adsorbent recovered from eggshell waste was developed.•Two preparation methods of hydration and sol–gel were used to obtain the adsorbents.•Sol-gel method led to an adsorbent with fluffier structure and higher porosity.•Prepared adsorbents were subjected to calcination/carbonation cycles in TGA.•Adding 7.5 wt% SiO2 led to higher adsorption capacity and proper fluidity. The reduction, storage, and reuse of greenhouse gas carbon dioxide (CO2) is a crucial concern in modern society. Bio-waste adsorbents have recently aroused the investigator's attention as auspicious materials for CO2 capture. However, the adsorption capacity decaying and poor fluidizability during carbonation/calcination cycles of all natural adsorbents used in the calcium-looping process (CaL) are important challenges. The current study explores the performance of a novel SiO2-decorated calcium-based adsorbent recovered from eggshell waste in terms of both CO2 capture capacity and fluidity. Two preparation methods of hydration and sol–gel were used to obtain Ca-based adsorbents with different pore configurations and volumes. Modification of the adsorbents was applied by dry physically mixing with different weight percentages of hydrophobic SiO2 nanoparticles (NPs), in order to maintain stability and fluidity. The adsorbent prepared by the sol–gel method exhibited a fluffier structure with smaller grain sizes and higher porosity than that of prepared by the hydration method, leading to a 6.9 % increase in conversion at the end of the 20th cycle. Also, with the optimal amount of SiO2 nanoparticles, i. e. 7.5 wt%, the amount of CaO conversion obtained by sol–gel derived adsorbent was 27.59 % higher than that by pristine eggshell at the end of the 20th carbonation/calcination cycles. The fluidizability tests showed that the highest bed expansion ratio (2.29) was achieved for sol–gel derived adsorbent in the presence of 7.5 wt% silica nanoparticles which was considerably higher than the amount of 1.8 and 1.6 belonged to sol–gel derived adsorbent and pristine eggshell without silica at the gas velocity of ≈ 6.5 cm/s, respectively. The high adsorption capacity and proper fluidity of this novel and green calcium-based adsorbent promise its wide application.