Inverse influence of initial diameter on droplet burning rate in cold and hot ambiences: a thermal action of flame in balance with heat loss

• Published in: International journal of heat and mass transfer 2003-03, Vol.46 (7), p.1155-1169
• Main Authors: Xu, Guangwen, Ikegami, Masiki, Honma, Senji, Ikeda, Kouji, Ma, Xiaoxun, Nagaishi, Hiroshi, Dietrich, Daniel L., Struk, Peter M.
• Format: Article
• Language: English
• Subjects: Applied sciences; Combustion of liquid fuels; Combustion. Flame; Droplet combustion; Energy; Energy. Thermal use of fuels; Exact sciences and technology; Flame radiation; Initial diameter influence; Microgravity combustion; Soot; Theoretical studies. Data and constants. Metering
• ISSN: 0017-9310; 1879-2189
• DOI: 10.1016/S0017-9310(02)00397-6

Isolated droplet burning were conducted in microgravity ambiences of different temperatures to test the initial diameter influence on droplet burning rate that shows a flame scale effect and represents an overall thermal action of flame in balance with heat loss. The coldest ambience examined was room air, which utilized a heater wire to ignite the droplet. All other ambiences hotter than 633 K were acquired through an electrically heated air chamber in a stainless steel can. An inverse influence of initial droplet diameter on burning rate was demonstrated for the cold and hot ambiences. That is, the burning rate respectively decreased and increased in the former and latter cases with raising the initial droplet diameter. The reversion between the two influences appeared gradual. In the hot ambiences the burning rate increase with increasing the initial droplet diameter was larger at higher temperatures. A “net heat” of flame that denotes the difference between “heat gain” by the droplet and “heat loss” to the flame surrounding was suggested responsible for the results. In low-temperature ambiences there is a negative net heat, and it turns gradually positive as the ambience temperature gets higher and the heat loss becomes less. Relating to luminous flame sizes and soot generation of differently sized droplets clarified that the flame radiation, both non-luminous and luminous, is determinative to the net heat in microgravity conditions. In addition, the work identified two peak values of soot generation during burning, which appeared respectively at the room temperature and at about 1000 K. The increase in ambience temperature made also bigger soot shells. The heat contribution of flame by both radiation and conduction was demonstrated hardly over 40% in the total heat required for droplet vaporization during burning in a hot ambience of 773 K.